Page 1 of 3

X Food Service Establishment
    Retail Food Store
    Temporary
    Mobile
KANKAKEE COUNTY HEALTH DEPARTMENT
DIVISION OF ENVIRONMENTAL HEALTH
2390 W. STATION STREET
KANKAKEE, IL 60901
(815) 802-9410, (815) 802-9411 (FAX)

FOOD SERVICE SANITARY INSPECTION REPORT
 Establishment #   BB026  
    Pre-opening
X Original Inspection
    Reinspection
   Follow-Up
    Possible FBI
    Complaint
   Other
Name of Establishment  JOE'S CATERING INC. D/B/A/ TUCCI'S ITALIAN Address  1560 STATE RT. 50 NORTH
Owner or Operator   JOE'S CATERING, INC. City   BOURBONNAIS Zip Code   60914
 
ITEM
X
WT
DESCRIPTION
ITEM
X
WT
DESCRIPTION
ITEM
X
WT
DESCRIPTION
 
FOOD
18
 
1
 Pre-flushed, scraped, soaked
34
  
1
 Outside storage area, enclosures properly constructed, clean: controlled incineration
*1
  
5
 Source, Wholesome, No Spoilage
19
  
2
 Wash, rinse after: clean, proper temperature
2
  
1
 Original Container, Properly Labeled
*20
  
4
 Sanitization rinse: Clean, temperature, concentration   INSECT, RODENT ANIMAL CONTROL
 
FOOD PROTECTION
*35
  
4
 Presence of insects/rodents - outer openings protected; no birds, turtles, or other animals
*3
X
5
 Potentially hazardous food meets temperature requirements during storage, preparation, display, service and transportation
21
  
1
 Wiping cloths: clean, use restricted
22
X
2
 Food contact surfaces of equipment and utensils clean, free of abrasives and detergents  
FLOORS WALLS AND CEILINGS
36
  
1
 Floor: constructed, drained, clean, good repair, covering installation, dustless cleaning methods
*4
  
4
 Facilities to maintain product temperature
23
X
1
 Non-food contact surfaces of equipment and utensils clean
5
X
1
 Thermometers provided and conspicuous
37
X
1
 Walls, ceiling, attached equipment: constructed good repair, clean surfaces, dustless cleaning methods
6
 
2
 Potentially hazardous food properly thawed
24
  
1
 Storage, handling of clean equipment utensils
*7
  
4
 Unwrapped and potentially hazardous food not re-served, Cross Contamination
25
  
1
 Single-service articles, storage, dispensing  
LIGHTING
26
  
2
 No re-use of single-service articles
38
  
1
 Lighting provided as required - Fixtures shielded
8
  
2
 Food protection during storage, preparation, display, service and transportation  
WATER
  
VENTILATION
*27
 
5
 Water source, safe: Hot and cold under pressure
39
  
1
 Rooms and equipment - vented as required
9
  
2
 Handling of food(ice) minimized, methods  
SEWAGE
  
DRESSING ROOMS
10
  
1
 Food(ice) dispensing utensils properly stored
*28
  
4
 Sewage and waste water disposal
40
  
1
 Rooms clean, lockers provided, facilities clean
 
PERSONNEL
  
PLUMBING
  
OTHER OPERATIONS
*11
  
5
 Personnel with infections restricted
29
  
1
 Installed, maintained
*41
  
5
 Toxic items properly stored, labeled and used
*12
  
5
 Hands washed and clean, good hygienic practices
*30
 
5
 Cross-connection, back siphonage-backflow
42
X
1
 Premises: maintained, free of litter, unnecessary articles, cleaning/maintenance equipment properly stored, authorized personnel
13
  
1
Clean clothes, hair restraints
  
TOILET AND HAND-WASHING FACILITIES
 
FOOD EQUIPMENT AND UTENSILS
14
  
2
 Food (ice) contact surfaces: designed, constructed, maintained, installed, located
*31
  
4
 Number, convenient, accessible, designed, installed
43
  
1
 Complete separation from living/sleeping quarters, laundry
32
 
2
 Toilet rooms enclosed, self-closing doors, fixtures, good repair, clean: Hand cleanser, sanitary towels/hand drying devices provided. Proper waste receptacles, tissue
15
X
1
 Non-food (ice) contact surfaces: designed, constructed, maintained, installed, located.
44
  
1
 Clean, soiled linen properly stored
 
CERTIFIED PERSONNEL
16
  
2
 Dishwashing facilities: designed, constructed, maintained, installed, located, operated
*45
     Management personnel certified Yes X No     Registered for class    
 
GARBAGE AND REFUSE DIPSOSAL
17
  
1
 Accurate thermometers, chemical test kits provided, gauge cook
33
  
2
 Containers or receptacles covered: adequate number, insect/rodent proof, frequency, clean
 
      
Sanitizer Requirement:  Chemical   chlorine 50-100 ppm                   Dishwasher Temperature   120-140 °F or label
Food Temperatures:   Brats 49° chicken 50° cheese 54° Ham 46°
 
General Comments
 
Report and Instructions Received By   /  
 
(Please Print)
  
(Signature of Owner or Representative)
Date  08/06/2007 Time In  2:15 PM Time Out  4:00 PM Sanitation Score  88 (100 Minus Demerits)
By  Steven Lamb (Sanitarian) Adjusted Score  88  
 
Page 2 of 3

    Food Service Establishment
    Retail Food Store
    Temporary
    Mobile
KANKAKEE COUNTY HEALTH DEPARTMENT
DIVISION OF ENVIRONMENTAL HEALTH
2390 W. STATION STREET
KANKAKEE, IL 60901
(815) 802-9410, (815) 802-9411 (FAX)

FOOD SERVICE SANITARY INSPECTION REPORT
 Establishment #   BB026  
    Pre-opening
X Original Inspection
    Reinspection
    Follow-Up__________
    Possible FBI
    Complaint
    Other______________
Name of Establishment  JOE'S CATERING INC. D/B/A/ TUCCI'S ITALIAN Address  1560 STATE RT. 50 NORTH
Owner or Operator   JOE'S CATERING, INC. City   BOURBONNAIS Zip Code   60914
 

ITEM
Remarks and Recommendations for Corrections
Corrected By
*3  Observed the following potentially hazardous foods to be held at improper temperatures. 1. Brats found at cold unit in ice at 49F. 2.Raw chicken found at 50F in True cooler. 3. Cheese found at 54F on top of reach in cooler to the far right. Provide for all cold potentially hazardous foods to be held at 41°F or below at all times except during necessary periods of preparation. 750. 120 Immediate/Onsite
5  Observed no thermometer to be available in the following units. 1. No visible thermometer in bar reach in cooler located under cash register. Provide for an accurate, conspicuous thermometer, that is accurate within +/- 3°F, to be available in all units holding potentially hazardous foods. 750.140 Immediate/Onsite
15  Observed the following improper non-food contact surfaces. Wire coat hangers being used for door handles on walk-in cooler door and freezer door. Replace with approved handles. Provide for all food contact surfaces to be smooth, easily cleanable, non-absorbant, corrosive resistant, and light colored. 750.690 Immediate/Onsite
22  Observed the following food contact surfaces to be unclean. The first and second shelf on the west side of walk-in cooler has food debris on it. Clean and maintain. 750.800 Immediate/Onsite
23  Observed the following non-food contact surfaces to be unclean. Fryers have grease and food debris in them. Clean and maintain. 2. Top of microwave has food debris on it. Microwave was cleaned. 3. Seal gaskets on walk-in freezer door has mold growth on it. 4. Seal gaskets on bar cooler are soiled. 5. Top of shelves where baskets are kept has dust and food debris on it. Clean and maintain all this equipment. 750.800 Immediate/Onsite
37  Obseved the following wall/ceilings, and attached equipment to be unclean: Wall above prep table is soiled. 2. Wall in corner located by the dishwasher is soiled and silicone needs to be replaced along wall to the left of the dishwasher. Provide for all walls, ceilings, and attached equipment to be in a clean condition. 750.1220 Immediate/Onsite
42  Observed the following unnecessary article(s) to be stored on the premises: 1. There is a reach in cooler that is not being used to the left of stoves. Remove this from the kitchen. Only articles necessary for the operation and maintenance of the food service establishment shall be stored on the premises. 750.1350 Immediate/Onsite
     
     
     
     
     
     
     
     
     
     
     
Report and Instructions Received By   /  
 
(Please Print)
  
(Signature of Owner or Representative)
Date  08/06/2007 Time In  2:15 PM Time Out  4:00 PM Sanitation Score  88 (100 Minus Demerits)
By  Steven Lamb (Sanitarian) Adjusted Score  88  
 
Page 3 of 3

    Food Service Establishment
    Retail Food Store
    Temporary
    Mobile
KANKAKEE COUNTY HEALTH DEPARTMENT
DIVISION OF ENVIRONMENTAL HEALTH
2390 W. STATION STREET
KANKAKEE, IL 60901
(815) 802-9410, (815) 802-9411 (FAX)

FOOD SERVICE SANITARY INSPECTION REPORT
 Establishment #   BB026  
    Pre-opening
X Original Inspection
    Reinspection
    Follow-Up__________
    Possible FBI
    Complaint
    Other______________
Name of Establishment  JOE'S CATERING INC. D/B/A/ TUCCI'S ITALIAN Address  1560 STATE RT. 50 NORTH
Owner or Operator   JOE'S CATERING, INC. City   BOURBONNAIS Zip Code   60914
 

ITEM
Remarks and Recommendations for Corrections
Corrected By
     
     
     
Report and Instructions Received By   /  
 
(Please Print)
  
(Signature of Owner or Representative)
Date  08/06/2007 Time In  2:15 PM Time Out  4:00 PM Sanitation Score  88 (100 Minus Demerits)
By  Steven Lamb (Sanitarian) Adjusted Score  88